A chimney sweep is a worker who clears ash and soot from chimneys. The chimney uses the pressure difference caused by a hot column of gas to create a draught and draw air over the hot coals or wood enabling continued combustion. Chimneys may be straight or contain many changes of direction. During normal operation a layer of soot builds up on the inside of the chimney restricting the flow. The soot can also catch fire, setting the chimney and the building alight. The chimney must be swept to remove the soot. This was done by the master sweep.
In the United Kingdom, the master sweeps took apprentices, who were boys from the workhouse or bought them from their parents and trained them to climb chimneys. Boys as young as four climbed hot flues that could be as narrow as 9in square using back, feet and knees to propel themselves. Work was dangerous and they could get jammed in the flue, suffocate or burn to death. As the soot was a carcinogen, and as the boys slept under the soot sacks and were rarely washed, they were prone to Chimney Sweeps Cancer. From 1775 onwards there was increasing concern for the welfare of the boys, and Acts of Parliament were passed to restrict, and in 1875 to stop this usage. Lord Shaftesbury, the philanthropist led the later campaign. In the United States, afro-american children were hired from their owners and used in the same way, and were still climbling after 1875.
In the German States, master sweeps belonged to trade guilds. and did not use climbing boys. In Italy, Belgium, and France climbing boys were used.
With the increased urban population that came with the Age of Industrialization, the number of houses with chimneys grew apace and the occupation of chimney sweep became much sought-after. Buildings were higher and the new chimneys tops were grouped together and the routes of flues from individual grates could involve two or more right angles and horizontal angled and vertical sections, The flues were made narrow to create a better draught- 14in by 9in being a common standard. Buckingham Palace had one flue with 15 angles, with the flue narrowing to 9in by 9in. Chimney sweeping was also one of the more commonly difficult, hazardous, and low-paying occupations of the era, and consequently has been derided in verse, ballad and pantomime. The first mechanical sweeping machine was invented by Smart in 1803 but was resisted in the UK and the US. John Glass marketed an improved sweeping machine in 1828; he is credited with being the inventor of the modern chimney sweeps brush. In the US Northern States, whites gave up the trade and and employed black sweep-boys from the South. After regulation finally took hold in 1875 in the UK and the turn of the century in the US, the occupation became romanticized in popular media and literature.
Chimneys started to appear in Britain around 1200, when they replaced the open fire burning in the middle of the one room house. At first there would be one heated room in the building and chimneys would be large. Over the next four hundred years rooms became specialised and smaller and many were heated. Sea coal started to replace wood, and it deposited a layer of flammable creosote in the inside surface of the flue, and caked it with soot. Whereas before, the chimney was a vent for the smoke now it was needed to draw the fire and this required narrower flues. Even so, boys rarely climbed chimneys before the Great Fire of London, when building regulations were put in place and the design of chimneys was altered, The new chimneys were often angular and narrow, and the usual dimension of the flue in domestic properties was 9 inches (23 cm) by 14 inches (36 cm). The master sweep was unable to climb into such small spaces himself and employed climbing boys to go up the chimneys to dislodge the soot. The boys often ‘buffed it’, that is, climbed in the nude, propelling themselves by their knees and elbows which were scraped raw. They were often put up hot chimneys, and sometimes up chimneys that were alight in order to extinguish the fire. Chimneys with sharp angles posed a particular hazard. These boys were apprenticed to the sweep, and from 1778 until 1875 a series of laws attempted to regulate their working conditions, and many first hand accounts were documented and published in parliamentary reports. From about 1803, there was an alternative method of brushing chimneys, but sweeps and their clients resisted the change preferring climbing boys to the new Humane Sweeping Machines. Compulsory education was established in 1870 by the Education Act 1870 but it was a further five years before legislation was put in place to license Chimney Sweeps and finally prevent boys being sent up chimneys.
A Seven flue stack in a four storey house with cellars. * A- is a hearth served by vertical flue, a horizontal flue, and then a vertical rise having two right-angled bends that were difficult for brushes. * B- is a long straight flue (14in by 9in) being climbed by a boy using back elbows and knees. * C- is a short flue from a second floor hearth. The climbing boy has reached the chimney pot, which has a diameter too small for him to exit that way * E- shows a disaster. The climbing boy is stuck in the flue, his knees jammed against his chin. * G- How a flue could be straighten to make it sweepable by mechanical means * H- A dead climbing boy, suffocated in a fall of soot that accumulated at the cant of the flue.
The climbing boys, and sometimes girls,were technically called chimney sweeps apprentices, and were apprenticed to a master sweep, who being an adult, was too large to fit into a chimney or flue. He would be paid by the parish to teach orphans or paupers the craft. They were totally reliant on him – they or their guardians had signed Papers of Indenture, in front of a magistrate, which bound them to him until they were adults. It was the duty of the Poor Law guardians to apprentice as many children of the workhouse in their care as possible, so as to reduce costs to the parish. The master sweep had duties: to teach the craft and its mysteries, to provide the apprentice with a second suit of clothes, to have him cleaned once a week, allow him to attend church, and not send him up chimneys that were on fire. An apprentice agreed to obey his master. Once his seven year long apprenticeship was completed he would become a journeyman sweep, and would continue to work for a master sweep of his choice. Other apprentices were sold on to the sweep, or sold by their parents. Prices ranged from 7 shillings to 4 guineas.
It was generally agreed that six was a good age to train a boy. Though Lord Shaftesbury once encountered one of the age of four, they were considered to be too weak. A master sweep would have many apprentices, they would start the morning by roaming the streets calling out “Soot -Oh, Sweep” or another cry to let the house-owners know they were around – this would remind the owners of the dangers of un-swept chimneys. When engaged, the master sweep would fix a cloth over the fireplace, and the climbing boy would take off his boots and any excess clothes, then get behind it. The flue would be as tall as the house and twist several times, and it’s dimensions would be 14in by 9in. He would pull his cap down over his face and hold a large flat brush over his head, and wedge his body diagonally in the flue. Using his back, elbows and knees, he would shimmy up the flue in the manner of a caterpillar and use the brush to dislodge loose soot, which would fall over him and down to the bottom, and a scraper to chip away the solid bits, as a smooth chimney was a safe chimney. Having reached the top he would slide back down at speed back to the floor and the soot pile. It was now his job to bag up the soot and carry it back to the master sweep’s cart or yard.
Soot was valuable and could be sold for 9d a bushel in 1840. An apprentice would do four or five chimneys a day. When they first started they scraped their knees and elbows, so the master would harden up their skin by standing them close to a hot fire and rubbing in strong brine using a brush. This was done each evening until the skin hardened. The boys got no wages but lived with the master who fed them. They slept together on the floor or in the cellar under the sacks and the cloth used during the day to catch the soot. This was known as “sleeping black” The boy would be washed by the mistress in a tub in the yard, this may happen as often as once a week, but rarely did. One sweep used to wash down his boys in the Serpentine. Another Nottingham sweep insisted they washed 3 times a year, for Christmas, Whitsun and the Goose Fair. Sometimes, a boy would need to be persuaded to climb faster or higher up the chimney, and the master sweep would either light a small fire of straw or a brimstone candle, to encourage him to try harder. Another method which also helped stop them from “going off” was to send another boy up behind him to prick pins into the soles of his feet or buttocks.
Chimneys varied in size. The common flue was designed to be one and a half bricks long by one brick wide, though the often narrowed to one brick square, that is 9 inches by 9 inches or less. Often the chimney would still be hot from the fire, occassionally it would actually be on fire. Careless climbing boys could get stuck with their knees jammed against their chins. The harder they struggled the tighter they became wedged. They could remain in this position for many hours until they were pushed out from below or pulled out with a rope. If their struggling caused a fall of soot they would suffocate. Dead or alive the boy had to be removed and this would be done by removing bricks from the side of the chimney. If the chimney was particularly narrow the boys would be told to “buff it”, that is to do it naked, otherwise they just wore trousers, and a shirt made from thick rough cotton cloth.
Health and Safety Concerns
The conditions to which these children were subjected caused concern and societies were set up to promote the means of mechanical means to sweep chimneys and it is through their pamphlets that we have a better idea of what the job could entail. Here a sweep describes the fate of one boy:
After passing through the chimney and descending to the second angle of the fireplace the Boy finds it completely filled with soot, which he has dislodged from the sides of the upright part. He endevours to get through, and succeeds in doing so, after much struggling as far as his shoulders; but finding that the soot is compressed hard all around him, by his exertions, that he can recede no farther; he then endevours to move forward, but his attempts in this respect are quite abortive; for the covering of the horizontal part of the Flue being stone, the sharp angle of which bears hard on his shoulders, and the back part of his head prevents him from moving in the least either one way or the other. His face, already covered with a climbing cap, and being pressed hard in the soot beneath him, stops his breath. In this dreadful condition he strives violently to extricate himself, but his strength fails him; he cries and groans, and in a few minutes he is suffocated. An alarm is then given, a brick-layer is sent for, an aperture is perforated in the Flue, and the boy is extracted, but found lifeless. In a short time an inquest is held, and a Coroner’s Jury returns a verdict of ‘Accidental Death.’ ”
These however were not the only occupational hazards that chimney sweeps suffered. In the 1817 report to Parliament witnesses reported that climbing boys suffered from general neglect, In addition they exhibited stunted growth and deformity of the spine, legs and arms, that, in the 1810s, was put down to being required to remain in abnormal positions for long periods of time before their bones had hardened.. The knees and ankle joints were the most affected. Sores and inflammation of the eyelids that could lead to loss of sight, were slow in healing because the boy kept rubbing them. Bruises and burns were obvious hazards of having to work in a overheated environment. Cancer of the scrotum, was only found in Chimneys sweeps so was referred to as Chimney Sweep Cancer in the teaching hospitals. Asthma and inflammation of the chest was attributed to the fact that the boys were out in all weathers,
Chimney sweeps cancer which the sweeps called soot wart didn’t occur until the sweep was in his late teens or twenties. It has now been identified as a manifestation of scrotal squamous cell carcinoma. It was reported in 1775 by Sir Percival Pott in climbing boys or chimney sweepers. It is the first industrially related cancer to be found.. Potts described it:
It is a disease which always makes it first attack on the inferior part of the scrotum where it produces a superficial, painful ragged ill-looking sore with hard rising edges…..in no great length of time it pervades the skin, dartos and the membranes of the scrotum, and seizes the testicle, which it inlarges(sic), hardens and renders truly and thoroughly distempered. Whence it makes its way up the spermatic process into the abdomen.
He also comments on the life of the boys:
The fate of these people seems peculiarly hard…they are treated with great brutality.. they are thrust up narrow and sometimes hot chimnies,(sic) where they are bruised burned and almost suffocated; and when they get to puberty they become … liable to a most noisome, painful and fatal disease.
The carcinogen was thought to be coal tar possibly containing some arsenic.
There were many deaths caused by accidents, frequently caused by the boy becoming jammed in the flue of a heated chimney, where they could suffocate or be burned to death Sometimes a second boy would be sent to help, and on occasions would suffer the same fate.
In 1788, the Chimney Sweepers Act 1788″: The Act had been partially inspired by the interest in climbing boys shown by Jonas Hanway, and his two publications The State of Chimney Sweepers’Young Apprentices (1773) and later Sentimental History of Chimney Sweeps in London and Westminster (1785). He asserted that while Parliament was exercised with the abolition of slavery in the new world it was ignoring the slavery imposed on climbing boys. He looked to Edinburgh Scotland where sweeps were regulated by the police, climbing was not allowed and chimneys were swept by the Master Sweep himself pulling bundles of rags up and down the chimney. He did not see how, climbing chimneys could be considered a valid apprenticeship as the only skill obtained was that of climbing chimneys which did not lead to future employment. Hanway advocated that Christianity should be brought into the boys lives and lobbied for Sunday Schools for the boys. The Lords removed the proposed clause that Master Sweeps should be licensed, and before civil registration, there was no way that anyone could check if a child was actually eight.
In the same year, David Porter, a humane master sweep, sent a petition to Parliament, and in 1792 published Considerations of the Present State of Chimney Sweepers with some Observations on the Act of Parliament intended for their Relief and Regulation. Though concerned for the boys welfare he believe that boys were more efficient that any of the new mechanical cleaning machines. In 1796 a society was formed for Bettering the Conditions of the Poor, and they encouraged the reading of Hanway and Porters tracts. They had influential members and royal patronage from George III. A Friendly Society for the Protection and Education of Chimney-Sweepers’ Boys had been established in 1800.
In 1803, it was thought by some that a mechanical brush could replace a climbing boy ( the Human brush), and members of the 1796 society formed The London Society for the Superseding the Necessity for Employing Climbing Boys, They ascertained that children had now cleaned flues as small as 7in by 7in, and promoted a competition for a mechanical brush. The prize was claimed by George Smart, for what in effect, was a brush head on a long segmented cane, made rigid by an adjustable cord that passed though the canes.
The Chimney Sweepers Act 1834 contained many of the needed regulations. It stated that an apprentice must express himself in front of a magistrate that he was willing and desirous. Masters must not take on boys under the age of fourteen. The master could only have six apprentices and an apprentice could not be lent to another master. Boys under fourteen who were already apprenticed, must wear brass cap badges on a leather cap. Apprentices were not allowed to climb flues to extinguished fires. Street cries were regulated. The act was resisted by the master sweeps and the general public believed that property would be at risk if the flues were not cleaned by a climbing boy.
Also that year building regulations relating to the construction of chimneys were changed.
The Chimney Sweepers and Chimneys Regulation Act 1840 made it illegal for anyone under the age of 21 to sweep chimneys. The 1840 Act was widely ignored, attempts were made in 1852 and 1853 to reopen the issue, another enquiry was convened and more evidence was taken. There was no bill. The Chimney Sweepers Regulation Act 1864, c37. tightened controls significantly, by authorising fines and imprisonment for master sweeps who were ignoring the law, giving the police the power of arrest on suspicion and authorising Board of Trade inspections of new and remodelled chimneys. Lord Shaftesbury was a main proponent of the Bill.
In February 1875 a twelve-year-old boy, George Brewster, was sent up the Fulbourn Hospital chimneys by his master, William Wyer. He stuck and smothered. The entire wall had to be pulled down to get him out and although he was still alive, he died shortly afterwards. There was a Coroner’s Inquest which returned a verdict of manslaughter. Wyer was sentenced to six months’ imprisonment with hard labour. Lord Shaftesbury seized on the incident to press his campaign again. He wrote a series of letters to The Times and in September 1875 pushed another Bill through Parliament which finally stopped the practice of sending boys up chimneys.
A Chimney Sweepers Act was passed in 1875 that required chimney sweepers to be authorised by the police to carry on their businesses in the district, this providing the legal means to enforce all previous legislation. George Brewster was the last child to die in a chimney.
Sweeping of the wide flues of these low buildings was often done by the householder himself, using a ladder to pass a wide brush down the chimney. In a narrow flue, a bag of bricks and brushwood would be dropped down the chimney. But in longer flues climbing boys were used, complete with the the UK tradition of coersion, and persuasion :using burning straw and pins in the feet and the buttocks. Sweeping was not a popular trade. During the eighteenth century the employment of Negro men and boys spread from the south to the north. Negro sweeps were not popular, and were thought to be inefficient and their shoddy work responsible for many fires. It was claimed that there were less fires in London where chimneys were swept by white boys than in New York. As in the UK, Smarts sweeping-machine was available in the US shortly after 1803, but few were used. Unlike the UK, there were no societies formed to advocate the climbing boys lot. The one novel produced in the states in 1854, championed the cause of ‘Tit’, a London climbing boy, contrasting his fate with the good conditions experienced by her Negro slave, ‘Tat’. Descriptions gleaned of the boys working conditions differ in one respect, the masters hired the sweep boys “from their owners”.
The London boys had one days holiday a year, that was May 1st, Mayday, International Labour Day. They celebrated by parading through the streets, dancing and twisting with Jack in the Green merging several folk traditions. There is also a Sweeps Festival in Santa Maria Maggiore, in Italy and in Rochester in Kent where the tradition was revived in 1980.
Good luck omen
In parts of Great Britain it is still considered lucky for a bride to see a chimney sweep on her wedding day. Many modern British sweeps hire themselves out to attend weddings in pursuance of this tradition.
In Poland and Croatia chimney sweeps still wear the traditional all-black uniform with a black hat. It is considered good luck to rub or grasp one of your buttons if you pass one in the street.
As a Lucky symbol, depictions of chimney sweeps are a popular New Year’s gift in Germany; either as small ornaments attached to flower bouquets or candy, e.g. marzipan chimney sweeps. Their traditional uniform is an all black suit with golden jacket buttons and a black tophat.